MATERIAL SAFETY DATA SHEET
Multicoat Corporation
23061 Arroyo Vista
Rancho Santa Margarita, CA 92688
Phone: 949-888-1700 Fax: 949-888-2555
Business Hours 8:00am - 5:00pm       

SECTION I  PRODUCT NAME & DESCRIPTION
Multicoat Joint Tape: White fabric tape with gray adhesive sealant                        
Chemical Family: Rubber                        
Formula: Proprietary       
SECTION IIA: HAZARDOUS INGREDIENTS
Hazardous Ingredients CAS# % OSHA PEL (ppm) Skin LD50 of ingredient
TWA STEL ceiling Designation mg/kg
Calcium Carbonate: 1317-65-3 5-10 N/A N/A N/A Orl-rat: 6,450
SECTION IIB  ADDITIONAL INGREDIENTS (>3%)
Additional Ingredients (> 3%): Inert Fillers and Hydrocarbon Resins
SECTION III  PHYSICAL DATA
Specific Gravity
1.25		   Boiling Point
314 F (157 C)		   % Volatiles by Wt.
NONE		   Vapor Density
Not Applicable
Vapor Pressure
Not Applicable		 Freezing Point
Not Established		 Solubility in Water
Not Soluble		 Evaporation Rate
Not Applicable
pH
Not Applicable		 Physical State
Soldi		 Odor Threshold
Not Applicable		 Corrosivity
Not Applicable
VOC
None		 Odor & Appearance
Gray tacky compound on backing or panel with mild rubber odor.  
SECTION IV:  FIRE & EXPLOSION HAZARD DATA
Flammability
Not Flammable		 Flashpoint
None - TCC		 Auto-Ignition Temp.
Not Applicable		 Lower Flammability Limit
Not Applicable		 Upper Flammability Limit
Not Applicable
SECTION V:  REACTIVITY DATA
This product is chemically stable.                 Hazardous polymerization will not occur.
Conditions to avoid: Keep away from excessive heat
Incompatibility: Avoid strong acids or strong oxidizing agents
Hazardous Decomposition Products:
Combustion may yield a variety of compounds such as CO, CO2, simple hydrocarbons, acids, aldehydes, ketones.
SECTION VI:  TOXICOLOGICAL PROPERTIES
Effects Of Acute Exposure To Product:
No known effects. Considered nontoxic and non-injurious.
Eye Contact: May cause mild mechanical irritation to eyes.
Skin Contact: May cause mild mechanical irritation on skin.
Ingestion or Inhalation: Very unlikely. Low order of acute oral toxicity.
Irritation: As noted above.
All evidence indicates that large polymer molecules are not biologically inactive.
Effects Of Chronic Exposure To Product:
No known effects. Considered nontoxic and non-injurious.
Exposure Limits: Not Established
Sensitization To Product: None Known
Irritancy Of Product: None Known
Synergistic Products: None Known
Carcinogenicity: No evidence
Mutagenicity & Tumorigenicity: No evidence
Reproductive Toxicity: No evidence
Teratogenicity: No evidence   
SECTION VII:  PREVENTIVE MEASURES
Eye Protection
Not Required		 Gloves
Cotton or other protective gloves
Respirator
Not Needed		 Foot Protection
Industrial shoes to prevent contact
Other: Long sleeves & long trousers to prevent skin contact.
Engineering Controls
Not Applicable		 Leak or Spill Procedure
Not Applicable

Waste Disposal:
Dispose of in accordance with all local, state, and federal regulations.
Handling Procedures & Equipment
Keep Out Of Reach Of Children.
Wash with soap and water after use, especially before eating, smoking, or drinking.
Storage Requirements
Keep away from excessive heat. Material may flow and could create a duration contact burn on hand.
Special Shipping Information
Item 35240 Class 55   

SECTION VIII:  FIRST AID MEASURES
Eye Contact
Do not remove. Get medical attention immediately.

Skin Contact
Care should be taken in the removal of the hot melt adhesive. Get medical attention if too sensitive.

Inhalation
Not applicable

Ingestion
Unlikely, but if ingested, it could create a blockage. Get medical attention.
SECTION IX:  SARA SECTION 313 SUPPLIER NOTIFICATION
This product contains the following toxic chemicals subject to the reporting requirements of Section 313 of the Emergency Planning & Community Right - to - Know Act of 1966 & of 40 CFR 372.    
SECTION X:  PREPARATION INFORMATION
PREPARED BY:
Research & Development		 Date:
24-Mar-98		 Revision #
5

SUPERSEDES ALL PREVIOUS PUBLICATIONS.   

back to MSDS SHEETS
back to Home Page  

please fill out our Feedback Form
to obtain more information

 Copyright © 2005 Multicoat Corporation.
All rights reserved.